Water Heater Release Valve Pipe

Temperature pressure relief or tpr valves are safety devices installed on water heating appliances such as boilers and domestic water supply heaters.

Water heater release valve pipe.

It starts from the slowly leaking of the water with the passage of time it become heavy flow of water with the pressure. Irc mechanical code section 70 5 water heater relief valves. This temperature pressure relief valve is attached to the discharge pipe. Water heaters come equipped with a temperature and pressure relief valve also known as a tprv.

Boiler pressure valves typically release water and steam at 30 psi not the 150 psi typical of water heater valves. 8 termination of the tpr drain pipe cannot be more than 6 inches or less than two pipe diameters above the floor ground or waster receptor. The drain valve is also become the cause of water leakage if the drainpipe or water heater overflow pipe water heater is loose. If the water heater itself isn t leaking the leak must be either in the hot water pipes or the hot water side of a faucet.

Other appliances like boilers for example also use pressure relief valves. Hold the tpr valve with the slip joint pliers. Wipe off any excess pipe joint compound with a damp rag. Section 608 5 upc 2009 relief valves located inside a building shall be provided with a drain not smaller than the relief valve outlet of galvanized steel hard drawn copper piping and fittings cpvc or listed relief valve drain tube with fittings which will not reduce the internal.

This valve allows water or steam to escape from the water heater if the temperature or pressure gets. Turning off the cold intake valve to the water heater not only turns off the water to the hot water heater but also to all the hot water pipes in the house. If temperature sensors and safety devices such as tprs malfunction water in the system may become superheated exceed the boiling point. While these valves operate in the same way as the one on your water heater they re set to go off at a much lower psi.

Our hot water heater started leaking from the temp. Turn the valve clockwise one additional turn to point the tpr valve outlet at the floor or at the nearest side of the water heater if the tpr valve is located on the top of the water heater. A trapped tpr dischage pipe is a common defect when a replacement water heater s tpr valve is lower than the original one and the installer connects to the exisitng discharge piping at the wall.